HYDAC冷卻器OK-EL2H/3.0/M/400-50/1熱銷型號
HYDAC冷卻器臥式冷油器具有壓降較小、抗水沖擊性強等特點，因此根據不同的場地、空間高度、使用性能等要求正確選用立式或臥式冷油器，能更好地滿足發電機組及其它設備的需要。
(1)HYDAC冷卻器打壓試驗合格后，方可投用，啟用前排盡內部存水。
使用注意事項
(1)冷卻器投用時,應打開冷卻線上放空閥排氣,見水后關閉,防止氣阻影響冷卻效果。
(2)冷卻器停運掃線時，停冷卻水，同時打開冷卻水放空閥，避免憋壓損壞設備。
(3)調節油品冷后溫度時，應先冷卻水出口閥控制。因?yàn)椴捎萌肟陂y控制水量，雖然可以節約冷水，但是會引起冷卻器內水流短路或流速減慢，造成上熱下涼影響換熱效果。故不宜用入口控制。
HYDAC冷卻器安裝方式分為立式冷油器和臥式冷油器，立式冷卻器具有所需安裝面積小、安裝方便等特點。
(2)HYDAC冷卻器檢查各倒淋、放空閥是否靈活好用及開關位置，壓力表、溫度計是否全部裝好。
(3)HYDAC冷卻器檢查基礎、支座是否牢固，各部螺栓是否滿扣、緊固。
(4)HYDAC冷卻器投用時，先投冷流，后投熱流。
(5)HYDAC冷卻器在投用冷介質或熱介質時，首先要保證副線暢通，再緩慢開出口閥，HYDAC冷卻器檢查無問題后開入口閥，一定要緩慢開，防止憋壓。投用過程要注意觀察設備變化情況。 HYDAC冷卻器投用后，隨著溫度壓力的變化，可能會出現泄漏現象HYDAC冷卻器，應及時進行檢查。
HYDAC冷卻器OK-EL2H/3.0/M/400-50/1熱銷型號
HYDAC冷卻器日常檢查：
HYDAC冷卻器投用后,操作人員應定期對換熱器進行巡回檢查,判斷其是否運行正常。
(1)HYDAC冷卻器檢查工藝參數，嚴禁超溫、超壓運行。
(2)HYDAC冷卻器檢查隔槽、大鍋、接口法蘭有無泄漏。
(3)HYDAC冷卻器檢查基礎支座的穩固情況。
(4)HYDAC冷卻器檢查冷卻器及管線的振動情況。
(5)HYDAC冷卻器定時查看油品顏色及換熱后的溫度變化。
HYDAC冷卻器日常維護
HYDAC冷卻器因冷卻水大多數含有鈣、鎂離子和酸式碳酸鹽。當冷卻水流經金屬表面時，有碳酸鹽的生成。另外，溶解在冷卻水中的氧還會造成金屬腐蝕，形成鐵銹。由于銹垢的產生，換熱效果下降。嚴重時不得不在殼體外噴淋冷卻水，結垢嚴重時會堵塞管子，使換熱效果失去作用。研究的數據顯示水垢沉積物對熱傳輸?shù)膿p失影響巨大，隨著沉積物的增加會造成能源費用的加大，節約能源、延長設備的使用壽命，同時節約生產時間和費用。
長期以來傳統的清洗方式如機械方法（刮、刷）、高壓水、化學清洗(酸洗)等在對設備清洗時出現很多問題：不能*清除水垢等沉積物，酸液對設備造成腐蝕形成漏洞，殘留的酸對材質產生二次腐蝕或垢下腐蝕，zui終導致更換設備，此外，清洗廢液有毒，需要大量資金進行廢水處理。
利用福世泰克清洗劑清洗凝汽器，福世泰克的高效、環保、安全、無腐蝕，不但清洗效果良好而且對設備沒有腐蝕，能夠保證凝汽器的長期使用。福世泰克清洗劑（*的添加濕潤劑和穿透劑，可以有效清除用水設備中所產生的zui頑固的水垢（碳酸鈣）、銹垢、油垢、粘泥等沉淀物，同時不會對人體造成傷害，不會對鋼鐵、紫銅、鎳、鈦、橡膠、塑料、纖維、玻璃、陶瓷等材質產生侵蝕、點蝕、氧化等其他有害的反應，可大大延長設備的使用壽命。

OK-EL2H/3.0/M/400-50/1
OK-EL3S/3.0/M/400-50/1
OK-EL4L/3.0/M/400-50/1
OK-EL1H/3.0/M/230-50-1/1
OK-EL2S/3.0/M/400-50/1
OK-EL3S/3.0/M/-/1 
OK-EL4S/3.0/M/A/1
OK-ELD6H/3.1/12V/1/S
OK-ELD5H/3.1/12V/1/S
OK-ELD4H/3.1/12V/1/S
OK-ELD3H/3.1/12V/1/S
OK-ELD2H/3.1/12V/1/S
OK-ELD1H/3.1/12V/1/S
OK-ELD1H/3.1/24V/1/S
OK-ELD2H/3.1/24V/1/S
OK-ELD3H/3.1/24V/1/S
OK-ELD4H/3.1/24V/1/S
OK-ELD5H/3.1/24V/1/S
OK-ELD6H/3.1/24V/1/S
OK-ELD3H/3.1/12V/1/S/AITF60
OKA-EL4S/28/3.0/M/400-50/1
OKA-EL4S/40/3.0/M/400-50/1
OKA-EL4L/40/3.0/M/400-50/1
OKA-EL4L/28/3.0/M/400-50/1
OK-EL4L/3.0/M/-/1 
OK-EL4S/3.0/M/-/1
OK-ELD4.5H/3.1/12V/1/S
OK-ELH5/1.0/H6.3/1/S
OK-ELC2H/1.0/400V/1/S
OKA-EL4L/40/3.0/M/-/1
OK-ELC3H/1.0/400V/1/S
OK-ELH3/1.0/H6.3/1/S
OK-ELH3/1.0/H14/1/S
OK-ELH5/1.0/H14/1/S
OK-ELH3/1.0/H22/1/S
OK-ELD1.5H/3.1/12V/1/S
OK-ELD1.5H/3.1/24V/1/S
OK-ELC4S/1.0/400V/1/S
OK-ELC5S/1.0/400V/1/S
OK-ELC6H/1.0/400V/1/S
OK-ELC7S/1.0/400V/1/S
OK-ELH4/1.0/H6.3/1/S
OK-ELH4/1.0/H14/1/S
OK-ELH4/1.0/H22/1/S
OK-ELD4.5H/3.1/24V/1/S
OK-ELH5/1.0/H22/1/S?    3107149
OK-ELC3H/1.0/230V/1/S
OK-ELC4S/1.0/230V/1/S
OK-ELC2H/1.0/230V/1/S
OK-ELC5S/1.0/230V/1/S
OK-ELH9/1.0/H14/1/S
OK-ELH9/1.0/H22/1/S
OK-ELC6H/1.0/230V/1/S
OK-ELC7S/1.0/230V/1/S
OK-ELC0H/1.0/230V/1/S
OK-ELC1H/1.0/400V/1/S
OK-ELC1H/1.0/230V/1/S
OK-ELD3H/3.1/24V/1/S/AITF60
OK-ELH2/1.0/H6.3/1/S
OK-ELH2/1.0/H14/1/S
OK-ELH2/1.0/H22/1/S
OK-ELH8/1.0/H6.3/1/S
OK-ELH8/1.0/H14/1/S
OK-ELH8/1.0/H22/1/S
OK-ELD4H/3.1/24V/1/S/AITF60
OK-ELH6/1.1/H6.3/1/S
OK-ELH6/1.1/H14/1/S
OK-ELH6/1.1/H22/1/S
OK-ELH11/1.0/H14/1/S
OK-ELH11/1.0/H22/1/S
OK-ELH10/1.0/H14/1/S
OK-ELH10/1.0/H22/1/S
OK-P9L/1.0/M/A/1
OK-P9LL/1.0/M/A/1
OK-P10LL/1.0/M/A/1
OK-P11LL/1.0/M/A/1
OK-P12LL/1.0/M/B/1
OK-P12LL/1.0/M/C/1
OK-ELD4.5H/3.1/24V/1/S/IBP3
WAERMETAU.OK-ELD5H/3.1/IBP
OK-ELD4H/3.1/24V/1/S/AITF50
OK-ELD3H/3.1/24V/1/S/IBP3
OK-ELD1H/3.1/12V/1/S/GP/FU
OK-ELD3H/3.1/12V/1/S/IBP2
OK-ELD5H/3.1/24V/1/S/IBP3
OK-ELD2H/3.1/12V/1/S/IBP3
OK-ELD1H/3.1/24V/1/S/GP/FU
OK-ELD4.5H/3.1/12V/1/S/IBP3/AITF60
OK-ELC4S/1.0/400V/1/S/AITF50
OK-ELD1H/3.1/24V/1/S/AITF50
OK-ELC1H/1.0/400V/1/S/AITF50
OK-ELD2H/3.1/12V/1/S/AITF50
OK-ELD5H/3.1/24V/1/S/FU
OK-ELD2H/3.1/24V/1/S/AITF50
WAERMETAU. SC-4/1.0 OK-EL4/3.0
OK-ELC5S/1.0/400V/1/S/AITF50
OK-ELH9/1.0/H14/1/S/IBP3
OK-ELC2H/1.0/400V/1/S/AITF50
OK-EL5L/3.0/M/A/1?    3172162
OK-ELD6H/3.1/24V/1/S/IBT45
OK-ELD4H/3.1/24V/1/S/IBT45
OK-EL2S/3.0/M/400-50/1/IBP3
OK-ELH9/1.0/H14/1/S/IBT45
OK-EL4S/3.0/M/A/1/IBT60
OK-ELD3H/3.1/24V/1/S/IBP2/AITF50
OK-ELD4H/3.1/24V/1/S/IBP3
OK-EL11LL/3.0/M/A/1?    3186232
OK-ELC3H/1.0/400V/1/S/IBT45
OK-ELH7/1.0/H14/1/S
OK-ELC3H/1.0/400V/1/S/AITF50
OK-ELD1.5H/3.1/12V/1/S/IBP2/AITF50
OK-ELD1H/3.1/12V/1/S/AITF60
OK-ELC4S/1.0/400V/1/S/IBT45
OK-ELD2H/3.1/24V/1/S/IBP3
OK-ELD4.5H/3.1/12V/1/S/IBP3
OK-ELC6H/1.0/400V/1/S/IBT45
OK-ELD3H/3.1/24V/1/S/IBT60
OK-ELC2H/1.0/230V/1/S/IBP3
OK-ELC2H/1.0/400V/1/S/IBP3
OK-ELD6H/3.1/12V/1/S/AITF50
OK-P8L/1.0/M/A/1
OK-ELD5H/3.1/24V/1/S/AITF50
OK-ELC1H/1.0/230V-3PH/1/S
OK-ELD3H/3.1/24V/1/S/IBT50/AITF60?    3207346
OK-ELH6/1.1/H14/1/S/IBP3
OK-ELC2H/1.0/400V/1/S/AITF60
OK-ELC4S/1.0/400V/1/S/IBP3
OKA-EL9LL/40/3.1/M/A/1
OK-ELC3H/1.0/230V/1/S/AITF50
OKAF-EL10LL/58/3.1/B/M/A/LPF280/4/1
OK-ELD4.5H/3.1/24V/1/S/IBP3/AITF60
OK-ELH8/1.0/H14/1/S/IBP3
OK-EL2S/3.0/M/400-50/1/IBT45
OK-ELD5H/3.1/24V/1/S/IBT45?    3224543
OK-ELD4.5H/3.1/12V/1/S/IBT45/AITF60
OK-ELD4.5H/3.1/24V/1/S/IBT45-2bar/AITF60
OK-ELC5S/1.0/230V/1/S/AITF50/IBP3?    3232419
OKAF-EL10LL/40/3.1/B/M/A/LF660B6/8/1
OK-ELD6H/3.1/12V/1/S/IBP3
OK-ELH8/1.0/H6.3/1/S/IBT45-2
OK-ELH8/1.0/H6.3/1/S/IBT45-3
OK-ELH11/1.0/H22/1/S/IBP3
OK-ELC3H/1.0/230V/1/S/IBT45-2
OK-ELH5/1.0/H22/1/S/IBT45
OK-ELD1H/3.1/12V/1/D
OK-ELD3H/3.1/12V/1/S/AITF50
OK-EL10LL/3.1/M/A/1?    3263639
BGR.LUEFTER OK-ELC0H/GRD
OK-ELD4H/3.1/24V/1/S/IBT45/AITF60
OK-ELD3H/3.1/24V/1/D/AITF60
OK-ELD4H/3.1/24V/1/S/IBP2/AITF50
OK-ELD3H/3.1/12V/1/S/IBT45/AITF50
OK-ELD2H/3.1/12V/1/S/IBT45
OK-ELH5/1.0/H6.3/1/S/IBP2
OK-EL3S/3.0/M/A/1/IBT60
OK-ELC2H/1.0/400V/1/S/IBT45-2
OK-ELH4/1.0/H14/1/S/IBT45-2
OK-ELD6H/3.1/12V/1/S/IBT45-3
OK-EL3H/3.1/M/400-50/1
OK-ELH8/1.0/H11/1/S/IBP3
OK-ELH5/1.0/H14/1/S/IBP3
OK-ELH2/1.0/H14/1/S/IBT45
OK-ELH8/1.0/H22/1/S/IBT45
OK-ELC4S/1.0/400V/1/S/IBP2/AITF50
OK-ELC7S/1.0/400V/1/S/IBT45
OKA-EL11L/69/5.0/M/A/1
OKAF-EL11L/40/5.0/B/M/A/LPF280/4/1
OKAF-EL11L/58/5.0/B/M/A/LPF280/4/1
OKAF-EL11L/69/5.0/B/M/A/LPF280/4/1
OKAF-EL11L/69/5.0/D24/M/A/LPF280/8/1
OK-EL11L/5.0/M/A/1
OK-EL11L/5.0/M/A/1/IBP3
OK-EL11L/5.0/M/A/1/IBT45
OK-EL11L/5.0/M/A/1/IBT60
OKA-EL10L/40/5.0/M/A/1
OKA-EL10L/69/5.0/M/A/1
OKAF-EL10L/40/5.0/B/M/A/LPF280/4/1
OKAF-EL10L/58/5.0/B/M/A/LPF280/4/1
OKAF-EL10L/69/5.0/B/M/A/LPF280/4/1
OK-EL10L/5.0/M/A/1
OK-EL10L/5.0/M/A/1/AITF50
OK-EL10L/5.0/M/A/1/IBT45-3bar
OKA-EL5S/28/5.0/M/A/1
OKA-EL5S/40/5.0/M/A/1
OKA-EL6S/28/5.0/M/A/1
OKA-EL6S/40/5.0/M/A/1